The Gozney Arc XL dimensions that matter most are its clearance zones, floor load and mouth limits, not only the size of the box. The official limits for the Arc XL help you pick a spot before you order a stand, cover or patio layout.
Every figure on this page comes from Gozney’s Arc and Arc XL technical manual. Where the manual does not give a number, this guide says so instead of guessing.
Gozney Arc XL Dimensions: Clearance Zones
The Gozney Arc XL dimensions for clearance call for 30 cm (about 12 inches) at the back and sides and 100 cm (about 39 inches) at the front from any combustible construction, according to the manual.
The manual is firm that the oven must never be placed under or on top of a combustible structure. Measure to the nearest wall, fence panel, railing or wooden surface, not just to the edge of your slab or patio.
The front zone is the one people underestimate when they plan a spot for the oven. A 100 cm front clearance gives you room to open the door, slide in a peel and turn a pizza without stepping onto a wall or railing.
| Zone | Manual requirement | Approximate imperial |
|---|---|---|
| Back and sides from combustible construction | 30 cm | about 11.8 in |
| Front from combustible construction | 100 cm | about 39.4 in |
| Air intake around the base of the dock | 2 in (50 mm) | 50 mm |
| Any structure, combustible material or gas cylinder while operating | 1.5 m | about 59 in |
| Flammable liquids while operating | 7.5 m | about 24.6 ft |
| Wind break distance from the oven | Over 45 cm | over about 17.7 in |
Keep the air intake clear. The manual asks for 2 inches (50 mm) of open space around the base of the dock, and nothing should block it because that area feeds air to the burner.
The clearance figures on this page are taken from the Arc and Arc XL technical manual, which covers both models in one document.
Weight, Floor Height and Surface for the Arc XL
The manual asks for a surface that can easily hold 25 kg (about 55 lb) for the Arc XL, compared with 20 kg (about 44 lb) for the standard Arc. Surface load is the figure that most affects which stand you buy, so plan the stand around it before you order one.
The surface must also be completely level and stable, which is part of the Gozney Arc XL dimensions you plan around. A table that wobbles under that load will shift every time you turn a pizza, so check it with a spirit level before you set the oven down.
For the Gozney Arc XL dimensions of height, the manual recommends a floor height of about 120 cm (roughly 47 inches), around the level of the bottom of your elbow. A lower spot means bending to load, and a higher one puts the door out of easy reach.
- Surface: completely level and stable.
- Load: able to hold 25 kg (about 55 lb), the Gozney Arc XL dimensions figure for weight.
- Height: about 120 cm (about 47 in) from the ground.
- Wind: mouth facing away from the wind, and no use in high winds.
Gozney Arc XL Dimensions Compared With the Arc
In the Gozney Arc XL dimensions and gas specs, the Arc XL uses a higher burner rating, a larger injector and a heavier surface load than the standard Arc, according to the manual’s gas and data tables. For what a propane-fired oven reaches in practice, see propane pizza oven temperatures.
| Spec | Arc | Arc XL |
|---|---|---|
| Model number | GOZ-1485 | GOZ-1728 |
| Burner rating (propane) | 14,400 BTU per hour | 17,500 BTU per hour |
| Injector size | 1.1 mm | 1.2 mm |
| Surface load rating | 20 kg (about 44 lb) | 25 kg (about 55 lb) |
| Gas type and pressure | Propane, 11 in W.C. | Propane, 11 in W.C. |
The table shows what changes on the Arc XL. It does not print an external size or a cooking chamber size, because the official numbers for those could not be confirmed from the manual. Retailer listings quote different figures for the Arc XL footprint and weight, so check the current numbers on Gozney’s US product page before you buy a stand or cover. If you are also weighing the Dome, the Gozney Dome dimensions are covered on a separate page.
Mouth Size and Loading Limits
Among the Gozney Arc XL dimensions, the mouth limit is simple: do not insert anything into the oven that is bigger than the oven mouth, and do not fill the cooking vessel beyond the limit set by the door dimensions, according to the manual.
The mouth is the real limit on what you can slide in. Check your peel, pan and pizza stone against the opening before you plan a bake, because a tool that is too wide will not pass through the door. Once the oven is placed, our Gozney Arc XL recipes guide covers what you can cook in it.
Do not cover the burner and do not overfill the oven. The manual also warns that water must never be poured onto the cooking stone, since it can crack the stone and is dangerous when oil or grease is present. For routine stone care, see how to clean a pizza stone.
Gas Hose and Enclosed Space Limits
The Arc XL is for outdoor use only, and the Gozney Arc XL dimensions for placement assume open air, so it must never be operated in an enclosed area, according to the manual’s safety section. For the wider question of weather and storage, see this guide on leaving a pizza oven outside.
Keep the oven away from any flammable material while it runs, and never use gas and wood at the same time. The manual also says the appliance is for cooking only, not for heating a room, and it must not be used on a boat or in a recreational vehicle. Treat those rules as part of your placement plan, not an afterthought.
If you disconnect the gas hose, put the quick-connect cover back on. If you smell gas, the manual says to shut off the gas supply, put out any open flame, keep away from the appliance and call your fire department.
Moving the Arc XL Without Damage
Lift the Arc XL by the hand holds on the underside edges, never by the mouth, and only when it is switched off and not hot.
- Remove anything loose and all transit packaging from inside the oven.
- Plan the route, clear obstacles, and confirm the oven fits through every door and gate.
- Check that the new spot meets the Gozney Arc XL dimensions for clearance and surface above.
- Lift from the underside hand holds, and do not move the oven while it is operating.
The manual also says Arc can stay hot for a few hours after use. Plan a move for later rather than right after a bake, and do not carry the oven unless you are confident you can lift it safely. Cleaning is easiest before a move, and the steps are in this guide to cleaning the Gozney Arc XL.
How to Measure Your Space Before You Buy
Mark the footprint of the oven, then add 30 cm behind and beside it and 100 cm in front. That total is the minimum clearance zone the manual sets, and it is the working core of any Arc XL space check.
- Find a flat area and confirm with a spirit level that it is level before you apply the Gozney Arc XL dimensions below.
- Add 30 cm (about 12 in) behind and beside the footprint for combustible construction.
- Add 100 cm (about 39 in) in front for the door and peel.
- Check that no structure, combustible material or gas cylinder sits within 1.5 m while the oven runs.
- Confirm the spot is not under a balcony, deck or apartment overhang.
Write each zone and its Gozney Arc XL dimensions figure down before you shop for a stand or cover. Gozney’s US manuals page lists the official documents if you want to check the wording yourself.
Frequently Asked Questions
How much space does the Arc XL need at the front?
The Gozney Arc XL dimensions call for 100 cm (about 39 inches) of clearance at the front from any combustible construction. That zone gives room to open the door, use a peel and stand clear of the mouth while the oven is hot.
What are the Gozney Arc XL dimensions for weight?
The manual gives 25 kg (about 55 lb) as the weight the supporting surface must easily hold for the Arc XL. The standard Arc uses 20 kg (about 44 lb). Use the underside hand holds and confirm you can lift the oven safely before you start.
Can I put the Arc XL on a balcony?
No. The manual says not to use Arc under any apartment, balcony or deck, and never on or under a combustible structure. Choose a level spot that meets the clearance zones above, and keep it at least 7.5 m from any flammable liquid.
What is the main difference between the Arc and the Arc XL?
The manual lists a burner rating of 17,500 BTU per hour for the Arc XL, against 14,400 for the Arc. It also gives the Arc XL a 1.2 mm injector, against 1.1 mm, and a 25 kg surface load rating instead of 20 kg.
Is the Arc XL safe to place near a wall?
Under the Gozney Arc XL dimensions in the manual, keep 30 cm from combustible construction at the back and sides, and 1.5 m from any structure, combustible material or gas cylinder while the oven runs. The manual also says it must never be placed under or on top of a combustible structure.
Where can I find the official Arc XL manual?
Gozney lists the Arc and Arc XL technical manual on its US manuals page, and the PDF is hosted on Gozney’s own store files. Read the current version before installation, because it is the most reliable source for the Gozney Arc XL dimensions on clearance and the gas figures.
Before you buy a stand, cover or patio spot, tape out the Gozney Arc XL dimensions on the ground, footprint and every clearance zone included. If any zone runs into a wall, railing, gas cylinder or overhang, move the oven or choose another spot, because the manual treats these limits as safety rules.